Convair CV-580

Conair Aviation

The aircraft was engaged in a fire fighting mission over the Fort McMurray area as 'Tanker 45'. Following an uneventful mission, the crew returned to Manning Airport. After landing on runway 25, the aircraft suffered directional control problems and veered off runway to the right. It collided with a drainage ditch, lost its nose gear and came to rest in a grassy area. The propeller separated from the right engine while the propeller on the left engine was bent. The fuselage broke in two just behind the cockpit area. Both pilots evacuated with minor injuries.

Nolinor Aviation

Following an uneventful flight from Winnipeg, the crew completed the landing on runway 02/20, a 1,876 metres long clay/gravel runway. During the landing roll, the nose gear collapsed. The aircraft slid on its nose for few dozen metres before coming to rest. All occupants evacuated safely and the aircraft was damaged beyond repair. At the time of the accident, the runway surface was irregular with potholes and water gouges due to the recent rains.

Nolinor Aviation

The crew was preparing the aircraft to perform a cargo flight to Calgary (flight NRL920). While taxiing, the aircraft went out of control, collided with a parked Ameriflight Piper PA-31 before coming to rest against a metallic fence. Both pilots were uninjured while the aircraft was damaged beyond repair.

Conair Aviation

Crew was fighting a forest fire near Siwash Road, about 15 km south of Lytton. The bombing run required crossing the edge of a ravine in the side of the Fraser River canyon before descending on the fire located in the ravine. About 22 minutes after departure, Tanker 448 approached the ravine and struck trees. An unanticipated retardant drop occurred coincident with the tree strikes. Seconds later, Tanker 448 entered a left-hand spin and collided with terrain. A post-impact explosion and fire consumed much of the wreckage. A signal was not received from the on-board emergency locator transmitter; nor was it recovered. Both crew members were fatally injured.

Air Tahoma

The accident flight was the first flight following maintenance that included flight control cable rigging. The flight was also intended to provide cockpit familiarization for the first officer and the pilot observer, and as a training flight for the first officer. About one minute after takeoff, the first officer contacted the tower and stated that they needed to return to land. The airplane impacted a cornfield about one mile southwest of the approach end of the runway, and 2 minutes 40 seconds after the initiation of the takeoff roll. The cockpit voice recorder (CVR) indicated that, during the flight, neither the captain nor the first officer called for the landing gear to be raised, the flaps to be retracted, or the power levers to be reduced from full power. From the time the first officer called "rotate" until the impact, the captain repeated the word "pull" about 27 times. When the observer pilot asked, "Come back on the trim?" the captain responded, "There's nothing anymore on the trim." The inspection of the airplane revealed that the elevator trim cables were rigged improperly, which resulted in the trim cables being reversed. As a result, when the pilot applied nose-up trim, the elevator trim system actually applied nose-down trim. The flight crew was briefed on the maintenance work that had been performed on the airplane; therefore, when the captain’s nose-up trim inputs were affecting his ability to control the airplane, at a minimum, he should have stopped making additional inputs and returned the airplane to the configuration it was in before the problem worsened. An examination of the maintenance instruction cards used to conduct the last inspection revealed that the inspector's block on numerous checks were not signed off by the Required Inspection Item (RII) inspector. The RII inspector did not sign the item that stated: "Connect elevator servo trim tab cables and rig in accordance with Allison Convair [maintenance manual]...” The item had been signed off by the mechanic, but not by the RII inspector. The card also contained a NOTE, which stated in bold type, "A complete inspection of all elevator controls must be accomplished and signed off by an RII qualified inspector and a logbook entry made to this effect." The RII inspector block was not signed off.

Saskatchewan Government Northern Air Operations

The aircraft was conducting stop-and-go landings on Runway 36 at the airport in La Ronge, Saskatchewan. On short final approach for the third landing, the aircraft developed a high sink rate, nearly striking the ground short of the runway. As the crew applied power to arrest the descent, the autofeather system feathered the left propeller and shut down the left engine. On touchdown, the aircraft bounced, the landing was rejected, and a go-around was attempted, but the aircraft did not attain the airspeed required to climb or maintain directional control. The aircraft subsequently entered a descending left-hand turn and crashed into a wooded area approximately one mile northwest of the airport. The first officer was killed and two other crew members sustained serious injuries. The aircraft sustained substantial damage. The accident occurred during daylight hours at 1245 central standard time.

LAC - Sky Congo

The aircraft departed Goma at 0930LT on a cargo flight to Amisi, carrying five passengers, three crew members and a load consisting of telecommunication equipments. On approach to Amisi Airport, the aircraft crashed in unknown circumstances, killing all eight occupants.

Bolivian Air Force - Fuerza Aérea Boliviana

Shortly after takeoff, while initial climb, the crew encountered engine problems and elected to make an emergency landing. The aircraft crash landed in a muddy field and came to rest, broken in two. 28 people were injured while 21 others escaped uninjured.

IFL Group

The 9,500-hour ATP-rated pilot was forced to secure the left engine during a maintenance test flight following the malfunction of the left propeller. The crew executed single-engine instrument landing system (ILS) approach to runway 13. During short final, the crew noticed that the alternator light was illuminated and the hydraulic pressure gauge indicated "0" pressure. The landing gear was already extended and the flaps were partially extended, so the crew elected to continue the approach to a full-stop landing. Upon landing, the pilot immediately turned on the direct current (DC) hydraulic pump. The pilot added that he then realized that he was unable to maintain directional control of the airplane due to the lack of nose wheel steering and the ineffective wheel brakes. As a result, the airplane continued to veer to the right and exited the runway. The airplane collided with the airport perimeter fence and continued down into a drainage ditch. The examination of the aircraft revealed that the hydraulic pump switch did not appear as if it had been turned on.

Air Freight NZ

On Friday 3 October 2003, Convair 580 ZK-KFU was scheduled for 2 regular return night freight flights from Christchurch to Palmerston North. The 2-pilot crew arrived at the operatorís base on Christchurch Aerodrome at about 1915 and together they checked load details, weather and notices for the flight. The flight, using the call sign Air Freight 642 (AF642), was to follow a standard route from Christchurch to Palmerston North via Cape Campbell non-directional beacon (NDB), Titahi Bay NDB, Paraparaumu NDB and Foxton reporting point. The pilots completed a pre-flight inspection of ZK-KFU and at 2017 the co-pilot (refer paragraph 1.10.4) called Christchurch Ground requesting a start clearance. The ground controller approved engine start and cleared AF 642 to Palmerston North at flight level 210 (FL 210) and issued a transponder code of 5331. The engines were started and the aircraft taxied for take-off on runway 20. At 2032 AF 642 started its take-off on schedule and tracked initially south towards Burnham NDB before turning right for Cape Campbell NDB, climbing to FL210. The flight progressed normally until crossing Cook Strait. After crossing Cape Campbell NDB, the crew changed to the Wellington Control frequency and at 2108 advised Wellington Control that AF 642 was at FL210, and requested to fly directly to Paraparaumu NDB. The change in routing was common industry practice and offered a shorter distance and flight time with no safety penalty. The Wellington controller approved the request and AF 642 tracked directly to Paraparaumu NDB. At 2113 the Wellington controller cleared AF 642 to descend initially to FL130 (13 000 feet (ft)). The co-pilot acknowledged the clearance. At 2122 the Wellington controller cleared AF 642 for further descent to 11 000 ft, and at 2125 instructed the crew to change to the Ohakea Control frequency. At 2125:14, after crossing Paraparaumu NDB, the co-pilot reported to Ohakea Control that AF 642 was in descent to 11 000 ft. The Ohakea controller responded 'Air Freight 642 Ohakea good evening, descend to 7000 ft. Leave Foxton heading 010, vectors [to] final VOR/DME 076 circling for 25. Palmerston weather Alfa, [QNH] 987.' At 2125:34 the co-pilot replied ìRoger down to 7000 and leaving Foxton heading 010 for 07 approach circling 25 and listening for Alfa. Air Freight 642. At 2125:44 the Ohakea controller replied 'Affirm, the Ohakea QNH 987.' The crew did not respond to this transmission. A short time later the controller saw the radar signature for AF 642 turn left and disappear from the screen. At 2126:17 the Ohakea controller attempted to contact AF 642 but there was no response from the crew. The controller telephoned Police and a search for AF 642 was started. Within an hour of the aircraft disappearing from the radar, some debris, later identified as coming from AF 642, was found washed ashore along Paraparaumu Beach. Later in the evening an aerial search by a Royal New Zealand Air Force helicopter using night vision devices and a sea search by local Coastguard vessels located further debris offshore. After an extensive underwater search lasting nearly a week, aircraft wreckage identified as being from ZK-KFU was located in an area about 4 km offshore from Peka Peka Beach, or about 10 km north of Paraparaumu. Police divers recovered the bodies of the 2 pilots on 11 October and 15 October.